15369665500 /15369665511
网站首页 关于我们
产品中心
59博案例
行业动态
资质荣誉
在线留言
联系我们

(迪瑞夫)金刚砂耐磨59博论坛 

发布时间:2017/10/27
(迪瑞夫)金刚砂耐磨59博论坛

   产品说明The Product Description
迪瑞夫彩色耐磨干撒式地面硬化剂由一定颗粒级配的矿物合金骨料或非金属骨料,特种水泥,其它掺合料和外加剂组成,开袋即可使用。将其均匀地撒布在即将初凝阶段的混凝土表面,经专门手段加工,从而使其与混凝土地面形成一个整体,且具有高致密性和着色的高性能耐磨地面。
Duraf color wear-resisting dry and type curing agent on the ground by a certain grain size distribution of mineral alloy aggregate or nonmetal aggregate, special cement, admixture and other admixtures, open bags can be used. It evenly over the initial setting stage concrete surface, processed by special means, making it the ground with concrete to form a whole, and high performance with high density and color wear-resisting surface.
 
技术指标Technical indicators
符合国家标准:JC/T 906-2002

 

项目
技术指标
检验结果
结论
I
II
抗折强度/Mpa
28d
≥11.5
≥13.5
12.5
合格
抗压强度/Mpa
28d
≥80.0
≥90.0
87.6
合格
表面强度(压痕直径),mm
≤3.30
≤3.10
2.7
合格
耐磨度比,%
≥330
≥335
335
合格

 

 
增强混凝土地面的耐磨性,耐冲击性度。极大提高了混凝土的密度,使其减少起尘,增加了地面的防油性,形成了一个高密度,易清洁,抗渗透的地面。与混凝土地面一起施工,施工工期短。耐久性好,减少了因周期性涂装或将表面增厚所带来的费用。
Reinforced concrete ground of wear resistance, resistance to impact. Greatly improve the density
of the concrete, make its reduce dust, increase defense oily ground, forming a high density,
easy to clean, the ground of the resistance to penetration. With the concrete construction,short
construction time limit for a project. Good durability, reduced because of the cyclical coating or will cost brought by the thickening of the surface.
 
产品颜色 Product Colour
水泥色、灰色、绿色、黄色、红色等。
The cement color, yellow, green, yellow, red, etc
铁绿Iron green    原色Primary colour   黑色BLACK 中灰Medium grey 浅灰
灰黑   进口铬绿  孔雀蓝     天蓝  黄色   铁红  浅蓝色  桔红  棕黄 59博论坛绿
 
适用范围Scope of application
适用于新浇筑混凝土施工,适用于室内外混凝土表面。
1、  工业厂房、生产车间
2、仓库、物流中心
3、车库、停车场
4、超市、卖场
Apply to the new pouring concrete construction, suitable for indoor and outdoor concrete surface.
1, Industrial Workshop, Production Workshop
2, Warehouse , Logistics center
3, Garage, Parking lot
4, Supermarkets, Stores
施工流程The construction process
1、混凝土基础浇筑
2、找平
3、撒布金刚砂
4、机械抹光
5、涂滚养护剂(养护)
1,Pouring concrete foundation 
2,Leveling
3,Scatter silicon carbide
4,Mechanical finishing
5,Roll coating curing agent(maintenance)
基础要求
◇ 基层混凝土强度要求达到C25以上,水灰比控制在0.50以下,混凝土塔落度应控制在70-100mm,混
   凝土拌合物尽量减少离析并对泌水有所控制。
◇ 为了确保混凝土拌合物有足够流动性及利于施工,建议混凝土加适当外加剂。
◇ 基层混凝土应参照优良混凝土的标准进行浇筑和振实,注意尺寸精确并减少浮浆产生。
◇ 硬化剂表面最好同混凝土结构层同时施工,如须同找平层同时施工,建议找平层混凝土采用细   石混凝土,厚度不低于50mm,并考虑配置伸缩钢筋网。
◇ 特别注意基层混凝土施工块的边角部位,保证该处混凝土振捣密实,并应采取额外加强处理。
 
The construction process
      Cardiac grassroots reach more than C25 concrete strength requirements, water cement ratio control in 0.50 the following, concrete tower should be controlled in 70-100 - mm, concrete mixture to minimize segregation and to control bleeding.
      Is left to make sure that the concrete mixture have enough liquidity and conducive to the construction, proposed concrete admixture appropriately.
      Derive concrete at the grass-roots level shall refer to the good of the standard of concrete pouring and vibrating, pay attention to the size precision and reduce the bleeding.
      Cardiac hardener surface layer with concrete structure construction at the same time, the best such as screed-coat construction at the same time, suggest using fine aggregate concrete, concrete leveling layer thickness of not less than 50 mm, and consider the configuration telescopic steel fabric.
      Has to pay special attention to grassroots edge position of the concrete block, ensure it concrete vibratory compaction, and should take extra strengthen processing.
(function(){ var bp = document.createElement("script"); bp.src = "//push.zhanzhang.baidu.com/push.js"; var s = document.getElementsByTagName("script")[0]; s.parentNode.insertBefore(bp, s); })();